Airport ground crew offload a plane carrying just under 300,000 doses of the single-shot Johnson & Johnson COVID-19 vaccine at Pearson International Airport during the COVID-19 pandemic on Wednesday, April 28, 2021. THE CANADIAN PRESS/Nathan Denette

Airport ground crew offload a plane carrying just under 300,000 doses of the single-shot Johnson & Johnson COVID-19 vaccine at Pearson International Airport during the COVID-19 pandemic on Wednesday, April 28, 2021. THE CANADIAN PRESS/Nathan Denette

Plans to distribute 1st doses of the Johnson & Johnson COVID-19 vaccine on hold

Health Canada had already cleared 1.5 million doses of the Oxford-AstraZeneca vaccine made at the facility

Plans to distribute the first 300,000 doses of the Johnson & Johnson COVID-19 vaccine next week are on hold after Health Canada learned part of them were manufactured at a Maryland facility that messed up the ingredients in 15 million doses bound for the U.S. market.

The Emergent Biosolutions facility in Baltimore was recently cited by the U.S. Food and Drug Administration for violations including cleaning and sterilization failures, the potential for cross-contamination and failure to follow required protocols.

The FDA ordered the facility to stop making more J&J vaccine until the problems are corrected and the earlier mistake on the doses resulted in all 15 million being destroyed.

Health Canada had already cleared 1.5 million doses of the Oxford-AstraZeneca vaccine made at the facility, but did not think the Canadian J&J doses had any connection to that plant.

Now Health Canada says the drug substance that makes up part of the J&J vaccine was actually produced there and then shipped elsewhere for the vaccines to be finished.

Health Canada says it is seeking information from the FDA and J&J’s pharmaceutical arm, Janssen, to determine if the 300,000 doses shipped to Canada meet required safety standards.

“As with all vaccines imported into Canada, the Janssen vaccines will only be released for distribution once Health Canada is satisfied that they meet the Department’s high standards for quality, safety and efficacy,” Health Canada said Friday evening in a release.

“Health Canada has rigorous processes in place to continually monitor the quality of vaccines that are administered to Canadians.

“We will continue to ensure that products coming from the Emergent facility, or any other facility, will only be imported and distributed in Canada if they are of high quality and safe for use.”

Until Friday, Health Canada had refused to say where Canada’s doses had been made, citing fear of disrupting a confidential supply chain.

The J&J vaccine has not been used in Canada so far, and the National Advisory Committee on Immunization hasn’t yet provided guidance on how they think it should be used.

The doses arrived in Canada on Wednesday and are in holding at the Innomar Strategies facility near Toronto’s Pearson airport. Innomar is contracted to receive and redistribute all vaccines in Canada, except Pfizer-BioNTech. That vaccine is shipped directly to provincial governments.

The Canadian Press

Like us on Facebook and follow us on Twitter.

Want to support local journalism? Make a donation here.

Coronavirus

Get local stories you won't find anywhere else right to your inbox.
Sign up here

Just Posted

Interfor’s Castlegar mill is getting $35 million in upgrades. Photo by: John Boivin
Interfor to invest $35 million at Castlegar mill

Project will enhance productivity and competitiveness

A medical worker prepares vials of the COVID-19 vaccines, Chinese Sinopharm, left, Sputnik V, center, and Pfizer at a vaccine centre, in the Usce shopping mall in Belgrade, Serbia, Thursday, May 6, 2021. Serbian authorities are looking for incentives for people to boost vaccination that has slowed down in recent weeks amid widespread anti-vaccination and conspiracy theories in the Balkan nation. The government has also promised a payment of around 25 euros to everyone who gets vaccinated by the end of May. (AP Photo/Darko Vojinovic)
38 new COVID-19 cases, more than 335k vaccines administered in Interior Health

Interior Health also to start targeted vaccinations in high transmission neighbourhoods

FILE PHOTO
Second doses of COVID-19 vaccine will be available, as AstraZeneca supply runs low: Interior Health

Province expecting large volumes of Pfizer BioNTech as age-based cohort immunization program ramps up

Greg Nesteroff and Eric Brighton, the historians behind popular Facebook page Lost Kootenays, are set to release a book of the same name and have just unveiled its cover showing the ghostly Hotel in Slocan City shortly before its 1953 demolition. Photo courtesy of Greg Nesteroff and Eric Brighton.
Popular historical Facebook page Lost Kootenays set to release book

128-page hard copy documenting history of East and West Kootenays coming this fall

Paul Chung is working as an early childhood educator at Cornerstone Children’s Centre in Nelson. Photo: Bill Metcalfe
Immigration pilot targets hard-to-fill jobs in West Kootenay

Program helps newcomers get permanent residency status in rural areas

Four homes in Johnson Flats were at serious risk of falling into a neighbourhood section of the Kettle River, according to capital project manager Justin Dinsdale. Photo: Laurie Tritschler
Grand Forks shields riverside homes against erosion

Crews have built a modified dike along a section of the Kettle River in Johnson Flats

Edmonton Oilers’ Connor McDavid (97) celebrates his 100th point this season with Leon Draisaitl (29) against the Vancouver Canucks during second period NHL action in Edmonton on Saturday, May 8, 2021.THE CANADIAN PRESS/Jason Franson
Edmonton superstar McDavid hits 100-point mark as Oilers edge Canucks 4-3

NHL scoring leader needs just 53 games to reach century mark

Nuns of Mother Teresa’s Missionaries of Charity, carry some of her relics during a vigil of prayer in preparation for the canonization of Mother Teresa in the St. John in Latheran Basilica at the Vatican, Friday, Sept. 2, 2016. In which city did she do much of her charitable work? (AP Photo/Gregorio Borgia)
QUIZ: How much do you know about these motherhood issues?

In honour of Mother’s Day, take this 10-question quiz

A map showing where the most number of cases were recorded from April 23 to 29. This map, revealing a breakdown of infections by neighborhood, was pulled from a data package leaked to the Vancouver Sun last week (and independently verified).
36 Abbotsford schools flagged for COVID-19 exposures in the last 2 weeks, shattering record

Clearbrook Elementary recorded an ‘exposure’ on all 11 school days

Canada’s chief public health officer is reminding Canadians even those who are fully vaccinated are not immune from transmitting the COVID-19. THE CANADIAN PRESS/Adrian Wyld
Canada’s top doctor warns full vaccination does not equal full protection from COVID-19

Post-inoculation, Theresa Tam says the risk of asymptomatic infection and transmission is far lower but not obsolete

The dash cam footage, taken May 7 at 8:18 a.m. belonged to the driver of a southbound vehicle that recently travelled out of the tunnel. (Reddit/Screen grab)
VIDEO: Dash cam captures dramatic rollover crash on Highway 99

Only one person sustained injuries from the collision, says B.C. Ambulance Services

Chevy stranded on a ledge above a rocky canyon at Mimi Falls near Logan Lake, April 28, 2021. (Photo credit: Margot Wikjord)
Police officer and fire chief team up in risky rescue of stranded dog near Logan Lake

Chevy, a rescue dog, needed rescuing again after getting stuck on a ledge above rocky canyon

Police were on the scene of a fatal shooting in Abbotsford. (Black Press Media files)
B.C. government to give more than $8 million for programs to curb gang violence

221 not-for-profit projects led by local governments and school districts among others will receive a one-time grant

Most Read